| Problem |
Cause |
Remedy |
Not getting hot water? |
a) The Jain Solar Product is located in shaded. |
a) Relocate in unshaded area during the day. |
| b) Wrong connection of cold water & hot water pipes to storage tank. |
b) Connect according to instructions. |
| c) Air is trapped in the collector or tank. If required, drain the system & fill it again. |
c) Open the collectors upper plug & remove the air. |
| d) Non Return valve stucked up. |
d) Remove & clean Non return valve spring. |
| e) Filter choked |
e) Remove the cap & clean the screen of the filter. |
Water is not coming? |
a) Pipes of hot or cold water in the storage tank are choked by sediment. |
a) Clean the pipes & descale sedimentation. |
b) Cold water tank is empty. |
b) Fill the overhead cold water tank. |
Hot water flow not smooth? |
a) Air vent for Hot/Cold water tank is not provided. |
a) Provide suitable ARV/Air vent for the both the tanks. |
Getting Luke warm water? |
a) Cloudy day. |
a) Use electrical backup, if provided. |
b) Collectors not cleaned. |
b) Remove dust accumulated on the collector. |
c) Mixing of cold & hot water. |
c) Check mixers & install the non return valve, if required. |
d) Hot water pipeline not insulated properly. |
d) Insulate the pipeline with suitable insulation. |
e) Scale formation in the collector. |
e) Descale the collector & use soft water to avoid this problem in future. |
Water is boiling in the collector? |
a) Not in use for a long time. |
a) Cover the collector with a shade. |
b) Failure of Thermostat. |
b) Change the Thermostat. |
Electrical backup not
working |
a) Wrong wiring connections. |
a) Connect according to the wiring diagram. |
b) Loose wiring connections. |
b) Locate, clean carefully & reconnect tightly. |
c) Lightening. |
c) Inspect / replace fuse, heater element & thermostat. |
d) Short circuit. |
d) Inspect / replace fuse, heater element & thermostat. |
e) Heater Thermostat failure. |
e) Replace with a new one. |
Home
